ECM Upgrade - MIL On With DTCs P0456 P0461 P050A P2188 P2192 P0128 P0326 P0441

“This site contains affiliate links for which OEMDTC may be compensated”

2015-146

SUBJECT:

ECM UPGRADE – RIO, SOUL MIL ON WITH DTC(S) P0456 / P0461 / P050A / P2188 / P2192 / P0128 / P0326 / P0441

This bulletin provides information related to the ECM software upgrade for some 2012~2014MY Rio (UB), some 2012~2013 Soul (AM) and some 2014MY Soul (PS) vehicles, which may experience a malfunction indicator lamp (MIL) illuminated with the Electronic Control Module (ECM) system-related DTCs; P0456, P0461, P050A, P2188, P2192, P0128, P0326, P0441. To correct this condition, the ECM should be reprogrammed using the GDS download as described in this bulletin. Before performing this procedure for a specific DTC concern, verify the VIN and DTC fall within the production ranges, by consulting the table on page 10. For confirmation that the latest reflash has been done to a vehicle you are working on, verify ROM ID using the tables in this TSB.

P0456: Evaporative Emission System-Leak detected (very small leak)
P0461: Fuel Level Sensor Circuit Range/Performance
P050A: Cold Start Idle Air Control System Performance
P2188: System too rich at idle (Bank 1)
P2192: System too rich at higher load (Bank 1)
P0128: Thermostat (Temp. below Thermostat Regulating Temp.)
P0326: Knock Sensor 1 Circuit Range/ Performance (Bank 1)
P0441: Evaporative Emission System Incorrect Purge Flow

UPGRADE EVENT NAME
238.UB 1.6GDI KNOCKING IMPROVEMENT
239.AM 1.6GDI KNOCKING IMPROVEMENT
255.PS 1.6GDI KNOCKING IMPROVEMENT

*NOTICE

A fully charged battery is necessary before ECM upgrade can take place. It is recommended that the Midtronics GR8-1299 system be used in ECM mode during charging. DO NOT connect any other battery charger to the vehicle during ECM upgrade.
All ECM upgrades must be done with the ignition key in the ‘ON’ position.
Be careful not to disconnect any cables connected to the vehicle or GDS during the ECM upgrade procedure.
DO NOT start the engine during ECM upgrade.
DO NOT turn the ignition key ‘OFF’ or interrupt the power supply during ECM upgrade.
When the ECM upgrade is completed, turn the ignition ‘OFF’ and wait 10 seconds before starting the engine.
ONLY use approved ECM upgrade software designated for the correct model, year.

ROM ID INFORMATION TABLES :

Upgrade event #238 (UB)

MODEL	T/M	ISG	IMMO	ECU P/N	ROM ID
MODEL	T/M	ISG	IMMO	ECU P/N	PREVIOUS	NEW
UB 1.6GDI	M/T	No (-)	No (-)	39110 2BDL0 39110 2BDN0 39110 2BDR0	GGUB-BNU6ES00600 GGUB-BNU6ES01600 GGUB-BNU6ES02600 GGUB-BNU6ES03600 GGUB-BNU6ES0060A GGUB-BNU6ES016A0 GGUB-DNU6ES00600 GGUB-DNU6ES01600 GGUB-DNU6ES02600 GGUB-DNU6ES03600 GGUB-DNU6ES04600 GGUB-DNU6ES05600 GGUB-DNU6ES06600 GGUB-ENU6ES01600	GGUB-ENU6EF01600
	A/T	No (-)	Yes (+)	39110 2BDM0 39110 2BDP0 39110 2BDS0	GGUB-BNU6FS00600 GGUB-BNU6FS01600 GGUB-BNU6FS02600 GGUB-BNU6FS03600 GGUB-BNU6FS0060A GGUB-BNU6FS016A0 GGUB-DNU6FS00600 GGUB-DNU6FS01600 GGUB-DNU6FS02600 GGUB-DNU6FS03600 GGUB-DNU6FS04600 GGUB-DNU6FS05600 GGUB-DNU6FS06600 GGUB-ENU6FS01600	GGUB-ENU6FF01600
		No (-)	No (-)	39110 2BDL5 39110 2BDA7 39110 2BDR5	GGUB-BNU6PS00C00 GGUB-BNU6PS01C00 GGUB-BNU6PS02C00 GGUB-BNU6PS03C00 GGUB-BNU6PS04C00 GGUB-BNU6PS00C0A GGUB-BNU6PS01CA0 GGUB-DNU6PS00C00 GGUB-DNU6PS01C00 GGUB-DNU6PS02C00 GGUB-DNU6PS03C00 GGUB-DNU6PS04C00 GGUB-DNU6PS05C00 GGUB-DNU6PS06C00 GGUB-ENU6PS01C00	GGUB-ENU6PF01C00
		No (-)	Yes (+)	39110 2BDM5 39110 2BDB7 39110 2BDS5	GGUB-BNU6QS00C00 GGUB-BNU6QS01C00 GGUB-BNU6QS02C00 GGUB-BNU6QS03C00 GGUB-BNU6QS04C00 GGUB-BNU6QS00C0A GGUB-BNU6QS01CA0 GGUB-DNU6QS00C00 GGUB-DNU6QS01C00 GGUB-DNU6QS02C00 GGUB-DNU6QS03C00 GGUB-DNU6QS04C00 GGUB-DNU6QS05C00 GGUB-DNU6QS06C00 GGUB-ENU6QS01C00	GGUB-ENU6QF01C00

Upgrade event #238 (UB) (cont.)

MODEL	TM	ISG	IMMO	ECM P/N	ROM ID
MODEL	TM	ISG	IMMO	ECM P/N	PREVIOUS	NEW
	A/T	Yes (+)	No (-)	39110 2BDL8 39110 2BDC7 39110 2BDR6	GIUB-BNU6PS00C00 GIUB-BNU6PS01C00 GIUB-BNU6PS02C00 GIUB-BNU6PS03C00 GIUB-BNU6PS04C00 GIUB-BNU6PS00C0A GIUB-BNU6PS01CA0 GIUB-BNU6PS02CA0 GIUB-DNU6PS00C00 GIUB-DNU6PS01C00 GIUB-DNU6PS02C00 GIUB-DNU6PS03C00 GIUB-DNU6PS04C00 GIUB-DNU6PS05C00 GIUB-DNU6PS06C00 GIUB-DNU6PS07C00 GIUB-DNU6PS08C00 GIUB-ENU6PS01C00	GIUB-ENU6PF01C00
		Yes (+)	Yes (+)	39110 2BDM8 39110 2BDD7 39110 2BDS6	GIUB-BNU6QS00C00 GIUB-BNU6QS01C00 GIUB-BNU6QS02C00 GIUB-BNU6QS03C00 GIUB-BNU6QS04C00 GIUB-BNU6QS00C0A GIUB-BNU6QS01CA0 GIUB-BNU6QS02CA0 GIUB-DNU6QS00C00 GIUB-DNU6QS01C00 GIUB-DNU6QS02C00 GIUB-DNU6QS03C00 GIUB-DNU6QS04C00 GIUB-DNU6QS05C00 GIUB-DNU6QS06C00 GIUB-DNU6QS07C00 GIUB-DNU6QS08C00 GIUB-ENU6QS01C00	GIUB-ENU6QF01C00
		Yes (+)	No (-)	39110 2BDE7	GIUB-DNU6PSG0C00 GIUB-DNU6PSG1C00 GIUB-DNU6PSG2C00 GIUB-DNU6PSG3C00 GIUB-DNU6PSG4C00 GIUB-DNU6PSG5C00 GIUB-DNU6PSG6C00 GIUB-DNU6PSG7C00 GIUB-DNU6PSG8C00	GIUB-DNU6PFG9C00
		Yes (+)	Yes (+)	39110 2BDF7	GIUB-DNU6QSG0C00 GIUB-DNU6QSG1C00 GIUB-DNU6QSG2C00 GIUB-DNU6QSG3C00 GIUB-DNU6QSG4C00 GIUB-DNU6QSG5C00 GIUB-DNU6QSG6C00 GIUB-DNU6QSG7C00 GIUB-DNU6QSG8C00	GIUB-DNU6QFG9C00

Upgrade event #239 (AM)

MODEL	T/M	ISG	IMMO	ECM P/N	ROM ID
MODEL	T/M	ISG	IMMO	ECM P/N	PREVIOUS	NEW
AM 1.6GDI	M/T	No (-)	No (-)	39110 2BCG0 39110 2BCJ0	GGAM BNU6ES00600 GGAM BNU6ES01600 GGAM BNU6ES02600 GGAM BNU6ES03600 GGAM BNU6ES04600 GGAM BNU6ES05600 GGAM BNU6ES06600 GGAM BNU6ES07600 GGAM BNU6ES08600 GGAM DNU6ES00600 GGAM DNU6ES01600 GGAM DNU6ES02600 GGAM DNU6ES03600 GGAM DNU6ES04600 GGAM DNU6ES05600	GGAM DNU6EF05600
	M/T	No (-)	Yes (+)	39110 2BCH0 39110 2BCK0	GGAM BNU6FS00600 GGAM BNU6FS01600 GGAM BNU6FS02600 GGAM BNU6FS03600 GGAM BNU6FS04600 GGAM BNU6FS05600 GGAM BNU6FS06600 GGAM BNU6FS07600 GGAM BNU6FS08600 GGAM DNU6FS00600 GGAM DNU6FS01600 GGAM DNU6FS02600 GGAM DNU6FS03600 GGAM DNU6FS04600 GGAM DNU6FS05600	GGAM DNU6FF05600
	A/T	No (-)	No (-)	39110 2BCG5 39110 2BCG2 39110 2BCC1	GGAM BNU6PS00C00 GGAM BNU6PS01C00 GGAM BNU6PS02C00 GGAM BNU6PS03C00 GGAM BNU6PS04C00 GGAM BNU6PS05C00 GGAM BNU6PS06C00 GGAM BNU6PS07C00 GGAM BNU6PS08C00 GGAM DNU6PS00C00 GGAM DNU6PS01C00 GGAM DNU6PS02C00 GGAM DNU6PS03C00 GGAM DNU6PS04C00 GGAM DNU6PS05C00 GGAM DNU6PS06C00 GGAM DNU6PS07C00	GGAM DNU6PF07C00
	A/T	No (-)	Yes (+)	39110 2BCH5 39110 2BCH2 39110 2BCD1	GGAM BNU6QS00C00 GGAM BNU6QS01C00 GGAM BNU6QS02C00 GGAM BNU6QS03C00 GGAM BNU6QS04C00 GGAM BNU6QS05C00 GGAM BNU6QS06C00 GGAM BNU6QS07C00 GGAM BNU6QS08C00 GGAM DNU6QS00C00 GGAM DNU6QS01C00	GGAM DNU6QF07C00

Upgrade event #239 (AM) (cont.)

MODEL	T/M	IMMO	ISG	ECU P/NO	ROM ID
PREVIOUS	NEW
AM 1.6 GDI	A/T	No (-)	Yes (+)	39110 2BCH5 39110 2BCH2 39110 2BCD1	GGAM DNU6QS02C00 GGAMDNU6QS03C00 GGAM DNU6QS04C00 GGAM DNU6QS05C00 GGAM DNU6QS06C00 GGAM DNU6QS07C00	GGAM DNU6QF07C00

MODEL

T/M

IMMO

ISG

ECU P/NO

ROM ID

NEW

AM 1.6 GDI

A/T

No (-)

Yes (+)

39110 2BCH5

39110 2BCH2

39110 2BCD1

GGAM DNU6QS02C00

GGAMDNU6QS03C00

GGAM DNU6QS04C00

GGAM DNU6QS05C00

GGAM DNU6QS06C00

GGAM DNU6QS07C00

GGAM DNU6QF07C00

Upgrade event #255 (PS)

MODEL	TM	ISG	IMMO	ECU P/NO	ROM ID
MODEL	TM	ISG	IMMO	ECU P/NO	PREVIOUS	NEW
PS 1.6GDI	M/T	No (-)	Yes (+)	39110 2BSG0	GGPS DNU6FS00600 GGPS DNU6FS01600	GGPS DNU6FF01600
	M/T	No (-)	Yes (+)	39110 2BSH0	GGPS DNU6ES00600 GGPS DNU6ES01600	GGPS DNU6EF01600
	A/T	No (-)	Yes (+)	39110 2BSG5	GGPS DNU6QS00C00 GGPS DNU6QS01C00	GGPS DNU6QF01C00
	A/T	No (-)	No (-)	39110 2BSH5	GGPS DNU6PS00C00 GGPS DNU6PS01C00	GGPS DNU6PF01C00

To verify the vehicle is affected, be sure to check the Calibration Identification of the vehicle’s ECM ROM ID and reference the Information Table as necessary.

*MANUAL MODE ECM UPGRADE PASSWORDS:

*Do NOT perform Manual Mode ECM upgrade unless Auto Mode fails.

Upgrade event #238 Rio (UB)

MY	MENU	PASSWORD
UB 1.6GDI	UB 1.6GDI MT -ISG -IMMO : 39110-2BDL0/N0	1020
	UB 1.6GDI MT -ISG +IMMO/SMK : 39110-2BDM0/P0	1021
	UB 1.6GDI AT -ISG -IMMO : 39110-2BDL5/A7	1027
	UB 1.6GDI AT -ISG +IMMO/SMK : 39110-2BDM5/B7	1028
	UB 1.6GDI AT +ISG -IMMO : 39110-2BDL8/C7	1029
	UB 1.6GDI AT +ISG +IMMO/SMK : 39110-2BDM8/D7	1030
	UB 1.6GDI AT +ISG -IMMO : 39110-2BDE7	1031
	UB 1.6GDI AT +ISG +IMMO/SMK : 39110-2BDF7	1032

Upgrade event #239 Soul (AM)

MY	MENU	PASSWORD
AM 1.6GDI	AM 1.6GDI MT -ISG -IMMO : 39110-2BCG0/J0	1020
	AM 1.6GDI MT -ISG +IMMO/SMK : 39110-2BCHO/K0	1021
	AM 1.6GDI AT -ISG -IMMO : 39110-2BCG5/G2/C1	1022
	AM 1.6GDI AT -ISG +IMMO/SMK : 39110-2BCH5/H2/D	1023

Upgrade event #255 Soul (PS)

MODEL	MENU	PASSWORD
PS 1.6GDI	PS 14MY MT -ISG -IMMO : 39110-2BSH0	1020
	PS 14MY MT -ISG +IMMO/SMK : 39110-2BSG0	1021
	PS 14MY AT -ISG -IMMO : 39110-2BSH5	1025
	PS 14MY AT -ISG +IMMO/SMK : 39110-2BSG5	1026

AFFECTED VEHICLE PRO DUCTION RANGE:

Model	MY	DTC	Production Date Range
Rio (UB)	2012~2013	P0456	From Job #1 to May 7, 2012
Soul (AM)	2012	P0456	From Job #1 to May 7, 2012
Rio (UB)	2012~2013	P0461	From Job #1 to Nov. 25, 2012
Soul (AM)	2012~2013	P0461	From Job #1 to Nov. 1, 2012
Rio (UB)	2012	P050A	From Job #1 to Mar 26 ,2012
Soul (AM)	2012	P050A	From Job #1 to Mar 26 ,2012
Rio (UB)	2012~2013	P2188 P2192	From Job #1 to Nov 24, 2012
Soul (AM)	2012~2013	P2188 P2192	From July 13,2011 to Nov 2, 2011
Rio (UB)	2012	P0128	From Job #1 to Dec 31, 2011
Soul (AM)	2012	P0128	From July 13, 2011 to Dec 31, 2011
Rio (UB)	2012~2014	P0326	All
Soul (AM)	2013
Soul (PS)	2014
Rio (UB)	2012~2014	P0441	All
Soul (AM)	2013
Soul (PS)	2014

Taking too long?

Reload document

Open in new tab

Download [554.37 KB]

What is J2534?

A single set of programming hardware consists of personal computer(PC), standard interface to a device driver and an interface hardware that connects between PC and a programmable ECU of vehicle.

The main purpose of this regulation is to program ECUs for all vehicles using a single set in the field.”

ECM Upgrade - MIL on with DTCs P0456 P0461 P050A P2188 P2192 P0128 P0326 P0441 - 2012-2014 Kia Rio & Soul | small light

Device	Manufacturers	API	DLL	Firmware
CarDAQ Plus	Drew Technologies Inc.	4.04	1.9.28	1.9.28
ES6510	Vetronix Corporation	4.04	12.00	12.00
Sun PassThru Pro	Snap-on Diagnostics	4.04	02.07u	02.07u
PassThru+ XS	I+ME Actia GmbH	4.04	02.07u	02.07u
OTTOTEST-VCI	OTTO	4.04	1.04	1.34
iFlash	Blue Streak	4.04	1.04	1.34
PASS THRU PRO II	Snap-on Diagnostics	4.04	1.9.24	1.9.24
AEZ Flasher	AE Tools	4.04	1.9.28	1.9.28
VSI-2534	Dearborn Tech	4.04	2.05.26	2.05.26
Flasher Pro	Bosch	4.04	1.9.28	1.9.28
Flash2	Cardone	4.04	2.06.28.2	2.06.28.2
PX3	Dearborn Tech	4.04	1.00.09	1.00.09
CARDAQ-M	Drew Technologies Inc.	4.04	1.0.106	1.0.106
Universal Reprogrammer II	EASE Diagnostics	4.04	1.9.28	1.9.28
G-Scan2	GIT	4.04	3.1	9.03

* API, DLL and Firmware version may be controlled by the device manufacturer. Contact the manufacturer if you are unable to find the version listed above All devices were tested/verified on all Kia eBay engine management systems.