| “This site contains affiliate links for which OEMDTC may be compensated” |
SUBJECT:
COMBINED TSB/SERVICE ACTION – RIO, SOUL 1.6 GDI MIL ON WITH DTCS P0456/P0461/P050A/P2188/P2192/P0128 (SA152)
This bulletin provides information related to the ECM software upgrade for some 2012-2013MY Rio (UB) and some 2012-2013 Soul (AM) vehicles which may experience a malfunction indicator lamp (MIL) illuminated with the Electronic Control Module (ECM) system-related DTCs; P0456, P0461,P050A, P2188, P2192, P0128. To prevent and/or correct this condition, the ECM should be reprogrammed using the GDS download as described in this bulletin. Before performing this procedure, verify the VIN falls within the production ranges by consulting the table on page 10. For confirmation that the latest reflash has been done to a vehicle you are working on, verify ROM ID using the tables in this TSB.
For vehicles not on the Affected Vehicles list, but with a customer concern as described above, perform the following procedure outlined in this bulletin and submit a warranty claim per “customer concern” (Standard TSB) claim information on page 11.
P0456: Evaporative Emission System-Leak detected (very small leak)
P0461 Fuel Level Sensor Circuit Range/Performance
P050A: Cold Start Idle Air Control System Performance
P2188: System too rich at idle (Bank 1)
P2192: System too rich at higher load (Bank 1)
P0128: Thermostat (temperature below Thermostat Regulating Temp.)
*NOTICE
DO NOT replace any parts related to the DTCs mentioned above unless proven to be the cause for the DTC AFTER the reflash has been performed. First perform the reflash as described in this bulletin, and verify that no DTC(s) will re-set. Should a DTC re-set after the reflash, diagnose according to KGIS. Parts replacement in conjunction with this TSB may be subject to Mandatory Parts Return and returned parts will be tested by KMA. Unnecessarily replaced parts will be subject to chargeback.
ECM Upgrade Procedure:
To correct this condition, the ECM should be reprogrammed using the GDS download as described in this bulletin.
| UPGRADE EVENT NAME |
|---|
| 198.UB 1.6 GDI P0456/P2188/P2192 DTC LOGIC IMPROVEMENT |
| 199.AM 1.6 GDI P0456/P2188/P2192 DTC LOGIC IMPROVEMENT |
*NOTICE
- A fully charged battery is necessary before ECM upgrade can take place. It is recommended that the Midtronics GR8-1299 system be used in ECM mode during charging. DO NOT connect any other battery charger to the vehicle during ECM upgrade.
- All ECM upgrades must be done with the ignition key in the ‘ON’ position.
- Be careful not to disconnect any cables connected to the vehicle or GDS during the ECM upgrade procedure.
- DO NOT start the engine during ECM upgrade.
- DO NOT turn the ignition key ‘OFF’ or interrupt the power supply during ECM upgrade.
- When the ECM upgrade is completed, turn the ignition ‘OFF’ and wait 20 seconds before starting the engine.
- ONLY use approved ECM upgrade software designated for the correct model, year.
CAUTION
Before attempting an ECM upgrade on any Kia
model, make sure to first determine whether the particular model is equipped with an immobilizer security system. Failure to follow proper procedures may cause the PCM to become inoperative after the upgrade and any claims associated with this repair may be subject to chargeback.
ROM ID INFORMATION TABLES:
Upgrade event #198 (UB)
| MODEL | MY | T/M | IMMO | ISG | ECM P/N | ROM ID | |
| PREVIOUS | NEW | ||||||
| RIO (UB) 1.6 GDI | 12MY | MT | No (-) | No (-) | 39110-2BDL0 | GGUB-BNU6ES00600 GGUB-BNU6ES01600 GGUB-BNU6ES02600 GGUB-BNU6ES03600 GGUB-BNU6ES04600 GGUB-BNU6ES0060A GGUB-BNU6ES016A0 GGUB-DNU6ES02600 | GGUB-DNU6ES05600 |
| Yes (+) | No (-) | 39110-2BDM0 | GGUB-BNU6FS00600 GGUB-BNU6FS01600 GGUB-BNU6FS02600 GGUB-BNU6FS03600 GGUB-BNU6FS04600 GGUB-BNU6FS0060A GGUB-BNU6FS016A0 GGUB-DNU6FS02600 | GGUB-DNU6FS05600 | |||
| AT | No (-) | No (-) | 39110-2BDL5 | GGUB-BNU6PS00C00 GGUB-BNU6PS01C00 GGUB-BNU6PS02C00 GGUB-BNU6PS03C00 GGUB-BNU6PS04C00 GGUB-BNU6PS00C0A GGUB-BNU6PS01CA0 GGUB-DNU6PS02C00 | GGUB-DNU6PS05C00 | ||
| Yes (+) | 39110-2BDL8 | GIUB-BNU6PS00C00 GIUB-BNU6PS01C00 GIUB-BNU6PS02C00 GIUB-BNU6PS03C00 GIUB-BNU6PS04C00 GIUB-BNU6PS00C0A GIUB-BNU6PS01CA0 GIUB-BNU6PS02CA0 GIUB-DNU6PS03C00 GIUB-DNU6PS04C00 | GIUB-DNU6PS06C00 | ||||
| Yes (+) | No (-) | 39110-2BDM5 | GGUB-BNU6QS00C00 GGUB-BNU6QS01C00 GGUB-BNU6QS02C00 GGUB-BNU6QS03C00 GGUB-BNU6QS04C00 GGUB-BNU6QS00C0A GGUB-BNU6QS01CA0 GGUB-DNU6QS02C00 | GGUB-DNU6QS05C00 | |||
| Yes (+) | Yes (+) | 39110-2BDM8 | GIUB-BNU6QS00C00 GIUB-BNU6QS01C00 GIUB-BNU6QS02C00 GIUB-BNU6QS03C00 GIUB-BNU6QS04C00 GIUB-BNU6QS00C0A GIUB-BNU6QS01CA0 GIUB-BNU6QS02CA0 GIUB-DNU6QS03C00 GIUB-DNU6QS04C00 | GIUB-DNU6QS06C00 | |||
ROM ID INFORMATION TABLES:
Upgrade event #198 (UB)
| MODEL | MY | T/M | IMMO | ISG | ECM P/N | ROM ID | |
|---|---|---|---|---|---|---|---|
| PREVIOUS | NEW | ||||||
| RIO (UB) 1.6 GDI | 13MY | MT | No (-) | No (-) | 39110-2BDN0 | GGUB-DNU6ES00600 GGUB-DNU6ES01600 GGUB-DNU6ES02600 GGUB-DNU6ES03600 GGUB-DNU6ES04600 | GGUB-DNU6ES05600 |
| Yes (+) | No (-) | 39110-2BDP0 | GGUB-DNU6FS00600 GGUB-DNU6FS01600 GGUB-DNU6FS02600 GGUB-DNU6FS03600 GGUB-DNU6FS04600 | GGUB-DNU6FS05600 | |||
| AT | No (-) | No (-) | 39110-2BDA7 | GGUB-DNU6PS00C00 GGUB-DNU6PS01C00 GGUB-DNU6PS02C00 GGUB-DNU6PS03C00 GGUB-DNU6PS04C00 | GGUB-DNU6PS05C00 | ||
| No (-) | Yes (+) | 39110-2BDC7 | GIUB-DNU6PS00C00 GIUB-DNU6PS01C00 GIUB-DNU6PS02C00 GIUB-DNU6PS03C00 GIUB-DNU6PS04C00 GIUB-DNU6PS05C00 | GIUB-DNU6PS06C00 | |||
| No (-) | Yes (+) | 39110-2BDE7 | GIUB-DNU6PSG0C00 GIUB-DNU6PSG1C00 GIUB-DNU6PSG2C00 GIUB-DNU6PSG3C00 GIUB-DNU6PSG4C00 GIUB-DNU6PSG5C00 | GIUB-DNU6PSG6C00 | |||
| Yes (+) | No (-) | 39110-2BDB7 | GGUB-DNU6QS00C00 GGUB-DNU6QS01C00 GGUB-DNU6QS02C00 GGUB-DNU6QS03C00 GGUB-DNU6QS04C00 | GGUB-DNU6QS05C00 | |||
| Yes (+) | Yes (+) | 39110-2BDD7 | GIUB-DNU6QS00C00 GIUB-DNU6QS01C00 GIUB-DNU6QS02C00 GIUB-DNU6QS03C00 GIUB-DNU6QS04C00 GIUB-DNU6QS05C00 | GIUB-DNU6QS06C00 | |||
| Yes (+) | Yes (+) | 39110-2BDF7 | GIUB-DNU6QSG0C00 GIUB-DNU6QSG1C00 GIUB-DNU6QSG2C00 GIUB-DNU6QSG3C00 GIUB-DNU6QSG4C00 GIUB-DNU6QSG5C00 | GIUB-DNU6QSG6C00 | |||
To verify the vehicle is affected, be sure to check the Calibration Identification of the vehicle’s ECM ROM ID and reference the Information Table as necessary.
ROM ID INFORMATION TABLES:
Upgrade event #199 (AM)
| MODEL | MY | T/M | IMMO | ISG | ECM P/N | ROM ID | |
|---|---|---|---|---|---|---|---|
| PREVIOUS | NEW | ||||||
| SOUL (AM) 1.6
GDI | 12MY | MT | No (-) | No (-) | 39110-2BCG0 | GGAM-BNU6ES00600 GGAM-BNU6ES01600 GGAM-BNU6ES02600 GGAM-BNU6ES03600 GGAM-BNU6ES04600 GGAM-BNU6ES05600 GGAM-BNU6ES06600 GGAM-BNU6ES07600 GGAM-BNU6ES08600 GGAM-DNU6ES01600 | GGAM-DNU6ES03600 |
| Yes (+) | No (-) | 39110-2BCH0 | GGAM-BNU6FS00600 GGAM-BNU6FS01600 GGAM-BNU6FS02600 GGAM-BNU6FS03600 GGAM-BNU6FS04600 GGAM-BNU6FS05600 GGAM-BNU6FS06600 GGAM-BNU6FS07600 GGAM-BNU6FS08600 GGAM-DNU6FS01600 | GGAM-DNU6FS03600 | |||
| AT | No (-) | No (-) | 39110-2BCG5
39110-2BCG2 | GGAM-BNU6PS00C00 GGAM-BNU6PS01C00 GGAM-BNU6PS02C00 GGAM-BNU6PS03C00 GGAM-BNU6PS04C00 GGAM-BNU6PS05C00 GGAM-BNU6PS06C00 GGAM-BNU6PS07C00 GGAM-BNU6PS08C00 GGAM-DNU6PS01C00 | GGAM-DNU6PS03C00 | ||
| Yes (+) | No (-) | 39110-2BCH5
39110-2BCH2 | GGAM-BNU6QS00C00 GGAM-BNU6QS01C00 GGAM-BNU6QS02C00 GGAM-BNU6QS03C00 GGAM-BNU6QS04C00 GGAM-BNU6QS05C00 GGAM-BNU6QS06C00 GGAM-BNU6QS07C00 GGAM-BNU6QS08C00 GGAM-DNU6QS01C00 | GGAM-DNU6QS03C00 | |||
| No (-) | Yes (+) | 39110-2BCG8
39110-2BCG3 | GIAM-BNU6PS00C00 GIAM-BNU6PS01C00 GIAM-BNU6PS02C00 GIAM-BNU6PS03C00 GIAM-BNU6PS04C00 GIAM-BNU6PS05C00 GIAM-BNU6PS06C00 GIAM-BNU6PS07C00 GIAM-BNU6PS08C00 | GIAM-DNU6PS03C00 | |||
| Yes (+) | Yes (+) | 39110-2BCH8
39110-2BCH3 | GIAM-BNU6QS00C00 GIAM-BNU6QS01C00 GIAM-BNU6QS02C00 GIAM-BNU6QS03C00 GIAM-BNU6QS04C00 GIAM-BNU6QS05C00 GIAM-BNU6QS06C00 GIAM-BNU6QS07C00 GIAM-BNU6QS08C00 | GIAM-DNU6QS03C00 | |||
ROM ID INFORMATION TABLES:
Upgrade event #199 (AM)
| MODEL | MY | T/M | IMMO | ISG | ECM P/N | ROM ID | |
|---|---|---|---|---|---|---|---|
| PREVIOUS | NEW | ||||||
| SOUL (AM) 1.6
GDI | 13MY | MT | No (-) | No (-) | 39110-2BCJ0 | GGAM-DNU6ES00600 GGAM-DNU6ES01600 GGAM-DNU6ES02600 | GGAM-DNU6ES03600 |
| Yes (+) | No (-) | 39110-2BCK0 | GGAM-DNU6FS00600 GGAM-DNU6FS01600 GGAM-DNU6FS02600 | GGAM-DNU6FS03600 | |||
| AT | No (-) | No (-) | 39110-2BCC1 | GGAM-DNU6PS00C00 GGAM-DNU6PS01C00 GGAM-DNU6PS02C00 | GGAM-DNU6PS03C00 | ||
| Yes (+) | No (-) | 39110-2BCD1 | GGAM-DNU6QS00C00 GGAM-DNU6QS01C00 GGAM-DNU6QS02C00 | GGAM-DNU6QS03C00 | |||
| No (-) | Yes (+) | 39110-2BCE1 | GIAM-DNU6PS00C00 GIAM-DNU6PS01C00 GIAM-DNU6PS02C00 | GIAM-DNU6PS03C00 | |||
| Yes (+) | Yes (+) | 39110-2BCF1 | GIAM-DNU6QS00C00 GIAM-DNU6QS01C00 GIAM-DNU6QS02C00 | GIAM-DNU6QS03C00 | |||
To verify the vehicle is affected, be sure to check the Calibration Identification of the vehicle’s ECM ROM ID and reference the Information Table as necessary.
NOTICE
If attempting to perform the ECM upgrade with the power supply cable disconnected from the GDS tool, be sure to check that the GDS tool is fully charged before ECM upgrade. If the GDS tool is not fully charged, failure to perform the ECM upgrade may occur. Therefore, it is strongly recommended that the power supply connector be connected to the GDS tool.
* MANUAL MODE ECM UPGRADE PASSWORDS:
* Do NOT perform Manual Mode ECM upgrade unless Auto Mode fails.
Upgrade event #198 Rio (UB)
| MY | MENU | PASSWORD |
|---|---|---|
| 12MY | UB 1.6 MT -IMMO -ISG : 39110-2BDL0 | 1020 |
| UB 1.6 MT +IMMO -ISG : 39110-2BDM0 | 1021 | |
| UB 1.6 AT -IMMO -ISG : 39110-2BDL5 | 1022 | |
| UB 1.6 AT -IMMO +ISG : 39110-2BDL8 | 1023 | |
| UB 1.6 AT +IMMO -ISG : 39110-2BDM5 | 1024 | |
| UB 1.6 AT +IMMO +ISG : 39110-2BDM8 | 1025 | |
| 13MY | UB 1.6 MT -IMMO -ISG : 39110-2BDN0 | 1026 |
| UB 1.6 MT +IMMO -ISG : 39110-2BDP0 | 1027 | |
| UB 1.6 AT -IMMO -ISG : 39110-2BDA7 | 1028 | |
| UB 1.6 AT -IMMO +ISG : 39110-2BDC7 | 1029 | |
| UB 1.6 AT -IMMO +ISG : 39110-2BDE7 | 1030 | |
| UB 1.6 AT +IMMO -ISG : 39110-2BDB7 | 1031 | |
| UB 1.6 AT +IMMO +ISG : 39110-2BDD7 | 1032 | |
| UB 1.6 AT +IMMO +ISG : 39110-2BDF7 | 1033 |
Upgrade event #199 Soul (AM)
| MY | MENU | PASSWORD |
|---|---|---|
| 12MY | AM 1.6 MT -IMMO -ISG : 39110-2BCG0 | 1020 |
| AM 1.6 MT +IMMO -ISG : 39110-2BCH0 | 1021 | |
| AM 1.6 AT -IMMO -ISG : 39110-2BCG5/CG2 | 1022 | |
| AM 1.6 AT +IMMO -ISG : 39110-2BCH5/CH2 | 1023 | |
| AM 1.6 AT -IMMO +ISG : 39110-2BCG8/CG3 | 1024 | |
| AM 1.6 AT +IMMO +ISG : 39110-2BCH8/CH3 | 1025 | |
| 13MY | AM 1.6 MT -IMMO -ISG : 39110-2BCJ0 | 1026 |
| AM 1.6 MT +IMMO -ISG : 39110-2BCK0 | 1027 | |
| AM 1.6 AT -IMMO -ISG : 39110-2BCC1 | 1028 | |
| AM 1.6 AT +IMMO -ISG : 39110-2BCD1 | 1029 | |
| AM 1.6 AT -IMMO +ISG : 39110-2BCE1 | 1030 | |
| AM 1.6 AT +IMMO +ISG : 39110-2BCF1 | 1031 |
AFFECTED VEHICLE PRODUCTION RANGE:
| Model | MY | DTC | Production Date Range |
|---|---|---|---|
| Rio (UB) | 2012~2013 | P0456 | From Job #1 to May 7, 2012 |
| Soul (AM) | 2012 | ||
| Rio (UB) | 2012 | P050A | From Job #1 to Mar 26 ,2012 |
| Soul (AM) | |||
| Rio (UB) | 2012~2013 | P2188 | From Job #1 to Nov 24, 2012 |
| Soul (AM) | P2192 | From July 13,2011 to Nov 2,2012 | |
| Rio (UB) | 2012 | P0128 | From Job #1 to Dec 31, 2012 |
| Soul (AM) | |||
| Rio (UB) | 2012~2013 | P0461 | From Job #1 to Nov. 25, 2012 |
| Soul (AM) | 2012~2013 | P0461 | From Job #1 to Nov. 1, 2012 |
Loading...
Reload document 
Open in new tab
What is J2534?
A single set of programming hardware consists of personal computer(PC), standard interface to a device driver and an interface hardware that connects between PC and a programmable ECU of vehicle.
The main purpose of this regulation is to program ECUs for all vehicles using a single set in the field.”
| Device | Manufacturers | API | DLL | Firmware |
|---|---|---|---|---|
| CarDAQ Plus | Drew Technologies Inc. | 4.04 | 1.9.28 | 1.9.28 |
| ES6510 | Vetronix Corporation | 4.04 | 12.00 | 12.00 |
| Sun PassThru Pro | Snap-on Diagnostics | 4.04 | 02.07u | 02.07u |
| PassThru+ XS | I+ME Actia GmbH | 4.04 | 02.07u | 02.07u |
| OTTOTEST-VCI | OTTO | 4.04 | 1.04 | 1.34 |
| iFlash | Blue Streak | 4.04 | 1.04 | 1.34 |
| PASS THRU PRO II | Snap-on Diagnostics | 4.04 | 1.9.24 | 1.9.24 |
| AEZ Flasher | AE Tools | 4.04 | 1.9.28 | 1.9.28 |
| VSI-2534 | Dearborn Tech | 4.04 | 2.05.26 | 2.05.26 |
| Flasher Pro | Bosch | 4.04 | 1.9.28 | 1.9.28 |
| Flash2 | Cardone | 4.04 | 2.06.28.2 | 2.06.28.2 |
| PX3 | Dearborn Tech | 4.04 | 1.00.09 | 1.00.09 |
CARDAQ-M  | Drew Technologies Inc. | 4.04 | 1.0.106 | 1.0.106 |
| Universal Reprogrammer II | EASE Diagnostics | 4.04 | 1.9.28 | 1.9.28 |
| G-Scan2 | GIT | 4.04 | 3.1 | 9.03 |
* API, DLL and Firmware version may be controlled by the device manufacturer. Contact the manufacturer if you are unable to find the version listed above All devices were tested/verified on all Kia engine management systems.
